1973 dodge 440 it will start but wont stay charged, repaired all wiring, new alternator, and everything un between has been replaced with new, can't figure out why it doesn't stay charged

Views: 137

Reply to This

Replies to This Discussion

Obviously you have a drain on the battery even though the key is turned off. Using an amp meter try disconnecting one wire at a time to find where the drain is coming from, when the particular wire is located, you can begin the tedious job of tracing where it goes and thus finding what is causing the battery drain.  Not easy by any means.  Try and get a good wiring diagram before you start, it may simplify your life.

Good Luck.

 Have the battery charged and remove a cable and let it sit all night and see if its discharged??? If so the battery itself must be bad, a shop will test it for free. If it stays charged if disconnected but runs down when connected, there must be a parasitic current draw but where??? Maybe try removing fuses one at a time to see which circuit is drawing the current??? If a circuit is drawing very much current you will get small sparks when the fuses are removed or plugged back in. An in line ammeter can measure the current draw.

 John T

Lifelong Dodge lover here, lots of experience with the older electrical systems.

I like to run a 10 ga wire straight from the back of the + terminal on the alt and run it around the front of the radiator to the battery + terminal. This bypasses the dash ammeter, with can be a problem over time. Install a voltmeter to get actual voltage readings.

Battery should have roughly 12.5V sitting, nominal voltage. Start the engine, volts should jump up to 13 + volts, up to around 14 volts.

The way I was taught to check for a draw is to disconnect one of the battery cables and put a test light inline from the removed cable to the battery post. There should be no light. If it lights up, you have a draw, start pulling fuses until you figure out which circuit is drawing, typically radio memory.

RSS

Members

HOW TO MEMBER POSTS

  •         How To Links 

-Search Good Old RV's

-Start a New Group 

-Roof Repair Photos & Products

-Repair an RV Roof

-Pick Roof Sealer   

-Understanding RV Electrical Systems 

-Get RV Insurance   

-What to Look For When Buying a Used RV

-Jack Installs Fuel Injection in his Dodge 

 RV ARTISTS 

 

 Artist Roads                                              

                      

JOIN US AT GOOD OLD RVS

If you love classic and vintage RVs then come Join us. Come on in and have some fun. JOIN HERE NOW

Forum

Starcraft Ceiling Repair

Started by Donald Morgenroth in RV Repair & Maintence Mar 18.

Replacing controller ,? And inverter 1 Reply

Started by Dave King in Vintage & Classic RV Restoration & Purchase. Last reply by Rick Cornell Apr 27, 2023.

Sway Bar Links 2 Replies

Started by Grey Wolf in RV Repair & Maintence. Last reply by Grey Wolf Apr 22, 2023.

Events

Videos

  • Add Videos
  • View All

JOIN US - COME ON IN!

If you love classic and vintage RVs then come Join us.

 Come on in and have some fun.      

 Dedicated to a simpler, more rewarding and fun way of life in a Good Old RV... 

Vintage Travel Trailers, Vintage Campers, Camper Restoration, Bus Conversions, Vintage RV Forums, Old RVs, Tiny Homes, Boondocking

A work of art by member Paige Bridges

+++++++++++++++++++++++++++++

 Disclaimer - Please Read it

Enjoy this site and use it totally at your own risk.

By using or viewing this site YOU agree to Hold Harmless anyone associated with it including other members. Also, YOU agree that YOU are solely responsible for ANY and ALL actions, results or damages. Members "opinions" are just that and any repair or alteration comments or recommendations are by folks who are not licensed repair  or mechanical professionals. Any repairs or modifications you do totally at YOUR OWN RISK. Use licensed professionals for all work to avoid possible serious injury or damage. Use  banks for purchases.  Have fun!

Copywrite & Trade Mark Registered GoodOldRV© ,GoodOldRVs©, GoodOldRVs.com©,GoodOldRVs.net©,GoodOldRV.Com©

© 2024   Created by Jimco_W001.   Powered by

Badges  |  Report an Issue  |  Terms of Service