Several years ago when deer hunting the water heater on my motor home made a loud explosion like noise. There was no damage to the water heater or the M/H but we shut it down anyway. Later we found the refrigerator had also shut down. We had been camping for four days when this occurred. We left camp and went to the nearest town with an RV repair center. They could not (or would not) give us an idea of what was happening unless we could leave the M/H with them for a couple of days so they could evaluate the problem. We decided to just finish our camping trip and take it back to our regular service center.

The service people there said it was most likely a low battery which would create the problem for both the water heater and the fridge. We by that time had recharged the batteries in the driving back and forth to the camp sight and then the drive back home and to our RV repair center. We did not have the problem again until a few months ago.

We were parked and on shore power when the same thing happened to the water heater; there was no problems with the fridge. We were setting inside when the water heater again made the explosion; as in the first time we could not see any damage or what may have caused it.

Does anyone have an idea what may have caused this? The water heater works great with the exception of these two incidents, both of which scared the socks of me. I was content with our RV service people suggestion that it was a low battery but this time it was on (and had been for several days) 110 volt, 30 amp commercial power.

Tags: ., rv Water heater

Views: 224

Reply to This

Replies to This Discussion

EXPLOSION? as in KABOOM? or maybe a POP or FART like sound?did you notice any water on or around the heater?did you check to see if the pop saftey valve might have caused this?what is the temperature of the hot water at a faucet? if the water heater makes a temp over 212 degrees,it will produce steam instead of hot water and the results will cause the pop saftey to open and dump the excess pressure.the pop saftey opening with the force of overpressure behind it can and will make a banging noise.

I appreciate your reply Brian; this problem has put us at edge too many times. The more replies I get the more I feel we may resolve the problem. Our RV technician didn't seem to think it was  anything major suggesting a low battery can cause it and we had been on DC power for several days when the first incident occurred; the second though was 110-AC.  I had thought maybe there was a problem with the igniter and some of the comments suggesting lack of air sounds acceptable. The hot water heater has never put out overly hot water as we keep it just warm enough for washing up.

Hopefully I will some day be able to thank everyone foe their help and explain what finally resolved the problem - again - thank you for the help.

Dwayne

Sounds like your Heating a void,,, in laymens terms, creating steam above the water level,, and occasionally if you have sediment on the bottom of the boiler box,(the inerds of the water heater), and steam builds under the sediment, and releases, making a pop, and if strong enough a boom,, amplified by the boiler box. (like a bongo drum). If your water heater is a couple years old,, its wise to shut it down and drain and pull the ionode rod out and check for the crunchy critters attached to it, Also pulling out the heating rod (s) (manufactures recommend they be changed during the life time of the water heater,,sometimes once,, sometimes several times depending on the hardness of the water). Calcium deposit wreak havoc on water heaters.Rememeber to always PURGE the air out of the water heater after plugging into shore power and having the water turned on.After getting all connected, let the water run thru the hot side of the water line for a couple minutes,(do the same for the cold side,incl, bath and sink fixtures). This will purge the air out of the lines, Let the water heater cycle itself warming up,, and after about 20 minutes (depends on how quick the water heater recovers to temp), Turn water spigot on the hot side on, to help purge the Steam that has accumilated. This should help,,,, If not, you have something that needs attention. Trust me,, you do NOT want to have a BAD blow out valve on a water heater,, it will make MORE then a mini Boom.

Many thanks for the information. Anyone of these may be the problem although we only keep our water at shower temperature.  I have never purged the air though so I will start doing so and hope that stops the problem.  I pull the drain plug (w/ionode rod attached) every time I drain the heater tank; It still looks pretty good.  Sounds like purging may be the order of the day and as I have not done so in the past doing it I the future will suggest that was what is needed.

Again - thank you.

Dwayne

I think your fridge going out was a coincidence. My HW heater will light with a scary loud boom occasionally. It also sometimes won't run with the door closed. I don't think it's getting enough air and the propane is building up until it ignites with a BANG! If I leave the door open it doesn't do this. Sorry I don't have any more info beyond that. I've been told to check the flame tube for obstructions but haven't gotten around to it.

Thank you; I appreciate any and all suggestions I get. I am afraid I won't get my wife back in the unit if this keeps up; and without her by my side there is no reason to be on the road. Thank you Jim.

RSS

Members

HOW TO MEMBER POSTS

  •         How To Links 

-Search Good Old RV's

-Start a New Group 

-Roof Repair Photos & Products

-Repair an RV Roof

-Pick Roof Sealer   

-Understanding RV Electrical Systems 

-Get RV Insurance   

-What to Look For When Buying a Used RV

-Jack Installs Fuel Injection in his Dodge 

 RV ARTISTS 

 

 Artist Roads                                              

                      

JOIN US AT GOOD OLD RVS

If you love classic and vintage RVs then come Join us. Come on in and have some fun. JOIN HERE NOW

Forum

Starcraft Ceiling Repair

Started by Donald Morgenroth in RV Repair & Maintence Mar 18.

Replacing controller ,? And inverter 1 Reply

Started by Dave King in Vintage & Classic RV Restoration & Purchase. Last reply by Rick Cornell Apr 27, 2023.

Sway Bar Links 2 Replies

Started by Grey Wolf in RV Repair & Maintence. Last reply by Grey Wolf Apr 22, 2023.

Events

Videos

  • Add Videos
  • View All

JOIN US - COME ON IN!

If you love classic and vintage RVs then come Join us.

 Come on in and have some fun.      

 Dedicated to a simpler, more rewarding and fun way of life in a Good Old RV... 

Vintage Travel Trailers, Vintage Campers, Camper Restoration, Bus Conversions, Vintage RV Forums, Old RVs, Tiny Homes, Boondocking

A work of art by member Paige Bridges

+++++++++++++++++++++++++++++

 Disclaimer - Please Read it

Enjoy this site and use it totally at your own risk.

By using or viewing this site YOU agree to Hold Harmless anyone associated with it including other members. Also, YOU agree that YOU are solely responsible for ANY and ALL actions, results or damages. Members "opinions" are just that and any repair or alteration comments or recommendations are by folks who are not licensed repair  or mechanical professionals. Any repairs or modifications you do totally at YOUR OWN RISK. Use licensed professionals for all work to avoid possible serious injury or damage. Use  banks for purchases.  Have fun!

Copywrite & Trade Mark Registered GoodOldRV© ,GoodOldRVs©, GoodOldRVs.com©,GoodOldRVs.net©,GoodOldRV.Com©

© 2024   Created by Jimco_W001.   Powered by

Badges  |  Report an Issue  |  Terms of Service